Development and validation of a quantitative minilab system for quality evaluation of selected medicines: Albendazole, arthemether-lumefantrine combination (Co-artem®), and mebendazole finished pharmaceutical products
The current technologies for substandard and counterfeit drug detection are either too expensive for low-resource settings or only provide qualitative or semi-quantitative results. GPHF minilab™ is one of them based on thin layer chromatography(TLC) principles with a semi-quantitative capability by visual observation of the spot area and intensity for medicine quality analysis. Thus, its use as a quality control tool for pharmaceutical products has limitations as spot area and intensity visual observation by the naked eye highly varies from analyst to analyst. As such, in this study, the semi-quantitative technique has been transferred to a quantitative approach by capturing the developed TLC plate image using an Android-based mobile phone inside a simple carton box. Then, the spot area was quantified using justTLC software. The quantitative results were compared with the-high performance liquid chromatography (HPLC) method as the golden standard. Accordingly, linearity was observed in the assayed range (80–120% label claim), and the correlation coefficients found were (R2 = 0.958, 0.997, 0.941, and 0.956 for Albendazole, Mebendazole, Artemether, and Lumefantrine, respectively.). The values are satisfactory. The %RSDs found were less than 2% for all drugs [intraday (n = 6) (RSD = 1.17, 1.61, 1.87, and 1.64), and interday (n = 18) (RSD = 1.16, 0.72, 1.12, and 1.18) for Artemether, Lumefantrine, Mebendazole, and Albendazole, respectively]. Moreover, comparisons of results obtained from the sophisticated CAMAG UV cabinet (R2 =0.991, 0.971, 0.946, and 0.967) and the developed simple carton box (R2 = 0.958, 0.997, 0.941, and 0.956) for Albendazole, Mebendazole, Artemether, and Lumefantrine, respectively. The values are comparable and reveal the accuracy of the method. Robustness testings' that were performed under different altered conditions revealed the robustness of the method (RSD less than 2% for all factors). Additionally the deviations from the golden HPLC results were on average −8.62% for albendazole, −3.79% for artemether, and −4.52% for lumefantrine samples. The developed method shows a satisfactory performance capability to utilize the GPHF minilab™ as a quantitative technique for medicine quality control purposes. It will be a very useful tool in a resource-limited setting. The target method profile, which encompasses a simple, low-cost, linear, precise, robust, accurate, and quantitative GPHF minilab™ system, was obtained for Albendazole, Mebendazole, and Arthemeter lumefantine combinations (Co-artem). The proposed method was successfully applied to analyze the content of the marketed medicines in the above mentioned tablets and offered acceptable deviations from the golden HPLC method. Automation of quantitative GPHF minilab™ was highly recommended to enhance the appropriateness and use of this system.
