Open Access

Coatings

, том 7 , издание 9 , страницы 142

Zircon-Based Ceramic Coatings Formed by a New Multi-Chamber Gas-Dynamic Accelerator

Тип публикации: Journal Article

Дата публикации: 2017-09-08

MDPI

Coatings

scimago Q2

wos Q2

white level БС2

SJR: 0.539

CiteScore: 5.4

Impact factor: 2.8

ISSN: 20796412

DOI: 10.3390/coatings7090142

Скопировать DOI

Materials Chemistry

Surfaces, Coatings and Films

Surfaces and Interfaces

Краткое описание

In this work, dense zircon-based ceramic coatings were obtained from inexpensive zircon powder on a steel substrate by using a new multi-chamber gas-dynamic accelerator. The microstructure and phase composition of the coating were characterized by scanning electron microscopy, optical microscopy, and X-ray diffraction. The mechanical properties of the coatings were evaluated using microindentation, wear tests and bonding strength tests. The results showed that the obtained zircon-based ceramic coatings were continuous without cracks and bonded well with substrate without a sublayer. The zircon-based ceramic coatings consisted of c-ZrO2 (major phase), m-ZrO2 and SiO2. The zircon-based ceramic coatings had a porosity of 0.1%, hardness of 526 ± 65 HV0.2, and a fracture toughness of 2.5 ± 0.6 (МPа∙m1/2). The coatings showed the low specific wear rate and average erosion rate. The failure mode occurring in the tested coatings was cohesive.

Для доступа к списку цитирований публикации необходимо авторизоваться.

Войти с ORCID

Для доступа к списку профилей, цитирующих публикацию, необходимо авторизоваться.

Войти с ORCID

Топ-30

Журналы

	1 2 3
Russian Engineering Research	Russian Engineering Research, 3, 18.75% Russian Engineering Research 3 публикации, 18.75%
Coatings	Coatings, 2, 12.5% Coatings 2 публикации, 12.5%
Materials Today: Proceedings	Materials Today: Proceedings, 1, 6.25% Materials Today: Proceedings 1 публикация, 6.25%
2019 IEEE 9th International Conference Nanomaterials: Applications & Properties (NAP)	2019 IEEE 9th International Conference Nanomaterials: Applications & Properties (NAP), 1, 6.25% 2019 IEEE 9th International Conference Nanomaterials: Applications & Properties (NAP) 1 публикация, 6.25%
Nanomaterials	Nanomaterials, 1, 6.25% Nanomaterials 1 публикация, 6.25%
Journal of the Australian Ceramic Society	Journal of the Australian Ceramic Society, 1, 6.25% Journal of the Australian Ceramic Society 1 публикация, 6.25%
International Journal of Applied Ceramic Technology	International Journal of Applied Ceramic Technology, 1, 6.25% International Journal of Applied Ceramic Technology 1 публикация, 6.25%
Journal of Asian Ceramic Societies	Journal of Asian Ceramic Societies, 1, 6.25% Journal of Asian Ceramic Societies 1 публикация, 6.25%
Minerals	Minerals, 1, 6.25% Minerals 1 публикация, 6.25%
Materials Science Forum	Materials Science Forum, 1, 6.25% Materials Science Forum 1 публикация, 6.25%
Key Engineering Materials	Key Engineering Materials, 1, 6.25% Key Engineering Materials 1 публикация, 6.25%
Ceramics International	Ceramics International, 1, 6.25% Ceramics International 1 публикация, 6.25%
Solid State Phenomena	Solid State Phenomena, 1, 6.25% Solid State Phenomena 1 публикация, 6.25%
	1 2 3

Издатели

	1 2 3 4
MDPI	MDPI, 4, 25% MDPI 4 публикации, 25%
Trans Tech Publications	Trans Tech Publications, 3, 18.75% Trans Tech Publications 3 публикации, 18.75%
Pleiades Publishing	Pleiades Publishing, 3, 18.75% Pleiades Publishing 3 публикации, 18.75%
Elsevier	Elsevier, 2, 12.5% Elsevier 2 публикации, 12.5%
Institute of Electrical and Electronics Engineers (IEEE)	Institute of Electrical and Electronics Engineers (IEEE), 1, 6.25% Institute of Electrical and Electronics Engineers (IEEE) 1 публикация, 6.25%
Springer Nature	Springer Nature, 1, 6.25% Springer Nature 1 публикация, 6.25%
Wiley	Wiley, 1, 6.25% Wiley 1 публикация, 6.25%
Taylor & Francis	Taylor & Francis, 1, 6.25% Taylor & Francis 1 публикация, 6.25%
	1 2 3 4

Мы не учитываем публикации, у которых нет DOI.
Статистика публикаций обновляется еженедельно.

Вы ученый?

Создайте профиль, чтобы получать персональные рекомендации коллег, конференций и новых статей.

Войти с ORCID

PDF

Метрики

Цитировать

ГОСТ |

Цитировать

ГОСТ Скопировать

Kovaleva M. et al. Zircon-Based Ceramic Coatings Formed by a New Multi-Chamber Gas-Dynamic Accelerator // Coatings. 2017. Vol. 7. No. 9. p. 142.

ГОСТ со всеми авторами (до 50) Скопировать

Kovaleva M., Prozorova M., Arseenko M., Tyurin Y., Kolisnichenko O., Yapryntsev M., Novikov V., Vagina O., Sirota V. Zircon-Based Ceramic Coatings Formed by a New Multi-Chamber Gas-Dynamic Accelerator // Coatings. 2017. Vol. 7. No. 9. p. 142.

RIS |

Цитировать

RIS Скопировать

TY - JOUR

DO - 10.3390/coatings7090142

UR - https://doi.org/10.3390/coatings7090142

TI - Zircon-Based Ceramic Coatings Formed by a New Multi-Chamber Gas-Dynamic Accelerator

T2 - Coatings

AU - Kovaleva, Marina

AU - Prozorova, Mayya

AU - Arseenko, Maria

AU - Tyurin, Yuri

AU - Kolisnichenko, Oleg

AU - Yapryntsev, Maxim

AU - Novikov, Vseslav

AU - Vagina, Olga

AU - Sirota, Viacheslav

PY - 2017

DA - 2017/09/08

PB - MDPI

SP - 142

IS - 9

VL - 7

SN - 2079-6412

ER -

BibTex |

Цитировать

BibTex (до 50 авторов) Скопировать

@article{2017_Kovaleva,

author = {Marina Kovaleva and Mayya Prozorova and Maria Arseenko and Yuri Tyurin and Oleg Kolisnichenko and Maxim Yapryntsev and Vseslav Novikov and Olga Vagina and Viacheslav Sirota},

title = {Zircon-Based Ceramic Coatings Formed by a New Multi-Chamber Gas-Dynamic Accelerator},

journal = {Coatings},

year = {2017},

volume = {7},

publisher = {MDPI},

month = {sep},

url = {https://doi.org/10.3390/coatings7090142},

number = {9},

pages = {142},

doi = {10.3390/coatings7090142}

}

MLA

Цитировать

MLA Скопировать

Kovaleva, Marina, et al. “Zircon-Based Ceramic Coatings Formed by a New Multi-Chamber Gas-Dynamic Accelerator.” Coatings, vol. 7, no. 9, Sep. 2017, p. 142. https://doi.org/10.3390/coatings7090142.

Издатель

MDPI

Журнал

Coatings

scimago Q2

wos Q2

white level БС2

SJR

0.539

CiteScore

5.4

Impact factor